America's Test Kitchen LogoCook's Country LogoCook's Illustrated LogoAmerica's Test Kitchen LogoCook's Country LogoCook's Illustrated Logo

Crispy-Creamy Sheet-Pan Macaroni and Cheese

By Rebeccah Marsters

Published on September 30, 2025

Time

40 minutes

Yield

Serves 4 to 6

Crispy-Creamy Sheet-Pan Macaroni and Cheese

Ingredients

1 pound elbow macaroni 8 ounces sharp cheddar cheese, shredded (2 cups), divided8 ounces American cheese, shredded (2 cups)1 (12‐ounce) can evaporated milk ½ cup sour cream 1¼ teaspoons table salt ½ teaspoon dry mustard 4 tablespoons unsalted butter, melted, divided¾ cup panko bread crumbs

Before You Begin

Buy an 8‐ounce block of American cheese from the deli rather than presliced cheese.

Instructions

  1. Adjust oven racks to upper-middle and lower-middle positions and heat oven to 400 degrees. Combine 1 pound elbow macaroni with 4 cups boiling water in large bowl. Cover and let sit for 12 minutes, stirring occasionally.
  2. Meanwhile, line rimmed baking sheet with parchment paper and sprinkle 1 cup shredded sharp cheddar cheese in center of sheet, spreading into rough 10 by 8‐inch rectangle. Bake on upper rack until cheese is browned and lacy, 8 to 12 minutes. Transfer sheet to wire rack and let cool slightly, then use spatula to slide crispy cheddar onto double layer of paper towels. Discard parchment, reserving sheet. Once cool enough to handle, break crispy cheddar into ½- to 1‐inch pieces; set aside.
  3. Reserve ½ cup soaking water, then drain pasta and return it to bowl. Add 2 cups shredded American cheese, remaining 1 cup shredded sharp cheddar cheese, and reserved soaking water and stir vigorously until most of cheese is melted (some small clumps of cheese will remain; that is OK) and water has been absorbed. Stir in 1 (12‐ounce) can evaporated milk, ½ cup sour cream, 1¼ teaspoons table salt, and ½ teaspoon dry mustard until well combined.
  4. Brush bottom and sides of now-empty sheet with 3 tablespoons melted unsalted butter. Transfer pasta mixture to sheet, being sure to scrape out any remaining cheese mixture in bowl, spreading into even layer if needed. Bake on lower rack until sauce is bubbling, 13 to 15 minutes.
  5. Meanwhile, toss ¾ cup panko bread crumbs with remaining 1 tablespoon melted butter in bowl until evenly coated. Microwave, stirring frequently, until light golden brown, 2 to 4 minutes.
  6. Remove sheet from oven and sprinkle crispy cheddar pieces and toasted panko evenly over top. Serve immediately.
Crispy-Creamy Sheet-Pan Macaroni and Cheese
Photography by Daniel J. van Ackere. Styling by Ashley Moore.

Crispy-Creamy Sheet-Pan Macaroni and Cheese

Headshot of Rebeccah Marsters
By Rebeccah Marsters

Published on September 30, 2025

Save

Time

40 minutes

Yield

Serves 4 to 6

Ingredients

1 pound elbow macaroni
8 ounces sharp cheddar cheese, shredded (2 cups), divided
8 ounces American cheese, shredded (2 cups)
1 (12‐ounce) can evaporated milk
½ cup sour cream
1¼ teaspoons table salt
½ teaspoon dry mustard
4 tablespoons unsalted butter, melted, divided
¾ cup panko bread crumbs

Ingredients

1 pound elbow macaroni
8 ounces sharp cheddar cheese, shredded (2 cups), divided
8 ounces American cheese, shredded (2 cups)
1 (12‐ounce) can evaporated milk
½ cup sour cream
1¼ teaspoons table salt
½ teaspoon dry mustard
4 tablespoons unsalted butter, melted, divided
¾ cup panko bread crumbs

Ingredients

1 pound elbow macaroni
8 ounces sharp cheddar cheese, shredded (2 cups), divided
8 ounces American cheese, shredded (2 cups)
1 (12‐ounce) can evaporated milk
½ cup sour cream
1¼ teaspoons table salt
½ teaspoon dry mustard
4 tablespoons unsalted butter, melted, divided
¾ cup panko bread crumbs

Why This Recipe Works

Who doesn’t love macaroni and cheese? And tailoring it to work on a sheet pan eliminates the need for multiple pots and lots of stirring. Our ingredient list was the same as our latest company version of mac n’ cheese, which relies on deli American cheese because it contains a lot of emulsifiers and makes a béchamel unnecessary. Here’s the basic technique and where the sheet pan comes in: After soaking the macaroni in boiling water and draining it, we toss it with the cheese and some reserved starchy water and stir vigorously. Then we add sour cream, evaporated milk, and mustard powder, all standard stuff. And yes, we spread this mixture on a sheet pan that we've brushed with butter. After about 15 minutes in the oven, what we see is a sheet pan full of creamy macaroni and cheese. Oh, did we mention the lovely frico we made on the sheet pan earlier? We break it into pieces and sprinkle it and some toasted bread crumbs over the top. Mission accomplished.

Before You Begin

Buy an 8‐ounce block of American cheese from the deli rather than presliced cheese.

Instructions

  1. Adjust oven racks to upper-middle and lower-middle positions and heat oven to 400 degrees. Combine 1 pound elbow macaroni with 4 cups boiling water in large bowl. Cover and let sit for 12 minutes, stirring occasionally.
  2. Meanwhile, line rimmed baking sheet with parchment paper and sprinkle 1 cup shredded sharp cheddar cheese in center of sheet, spreading into rough 10 by 8‐inch rectangle. Bake on upper rack until cheese is browned and lacy, 8 to 12 minutes. Transfer sheet to wire rack and let cool slightly, then use spatula to slide crispy cheddar onto double layer of paper towels. Discard parchment, reserving sheet. Once cool enough to handle, break crispy cheddar into ½- to 1‐inch pieces; set aside.
  3. Reserve ½ cup soaking water, then drain pasta and return it to bowl. Add 2 cups shredded American cheese, remaining 1 cup shredded sharp cheddar cheese, and reserved soaking water and stir vigorously until most of cheese is melted (some small clumps of cheese will remain; that is OK) and water has been absorbed. Stir in 1 (12‐ounce) can evaporated milk, ½ cup sour cream, 1¼ teaspoons table salt, and ½ teaspoon dry mustard until well combined.
  4. Brush bottom and sides of now-empty sheet with 3 tablespoons melted unsalted butter. Transfer pasta mixture to sheet, being sure to scrape out any remaining cheese mixture in bowl, spreading into even layer if needed. Bake on lower rack until sauce is bubbling, 13 to 15 minutes.
  5. Meanwhile, toss ¾ cup panko bread crumbs with remaining 1 tablespoon melted butter in bowl until evenly coated. Microwave, stirring frequently, until light golden brown, 2 to 4 minutes.
  6. Remove sheet from oven and sprinkle crispy cheddar pieces and toasted panko evenly over top. Serve immediately.

Gift This Recipe

Enjoyed this dish? Let others know by sharing it as a gift recipe.

Keep Exploring

This is a members' feature.